LEAF 2021

24 HR ORDERS 1-800-532-3462 ONLINECATALOG.LEADINGEDGEAIRFOILS.COM Prices and Supplies are subject to change without notice CABLE COMPONENTS / CONTROLS SPLITTER ASSEMBLIES Description Application Lengths Configuration Part No. Price Single Throttle and Oil Injection Splitter Assembly with Cables For single carb Rotax ® engines with oil injection. Splits one cable to carb and one to oil pump Rotax ® 503 requires H7338 bushing 19” & 35” plugs-down H7342 $13.60 Rotax ® 503 18” & 19” plugs-up H7341 $12.15 Dual Throttle Non-Oil injection Splitter Assembly with Cables For dual carb Rotax ® engines without oil injection. Splits one cable to each carb Rotax ® 447, 503, 532, 582, 618 14” & 19” H7335 $25.70 Dual Throttle and Oil Injection Splitter Assembly with Cables For dual carb Rotax ® engines with oil injection. Splits one cable to each carb and one to oil pump Rotax ® 503 requires H7338 bushing 14”, 19” & 35” plugs-down H7346 $37.90 Rotax ® 503, 582, 618 14”, 18” & 19” plugs-up H7345 $37.50 Oil Injection Cable Only Includes the components required to add an oil injection cable to an existing dual carb throttle splitter. Rotax ® 503 requires H7338 bushing. Rotax ® 503, 582, 618 18” plugs-up H7339 $11.00 35” plugs-down H7331 $18.95 Dual Choke Splitter Assembly with Cables For remote chokes on dual carb Rotax ® engines. Splits one choke cable to each carb Rotax ® 503, 582, 618 14” & 19” H7340 $29.90 Choke Splitter Assembly with Cables Rotax ® 912 16” & 27-1/2” H7352 $16.95 Measurements are taken from the cable housing. CABLE COMPONENTS Description Part No. Price Wire Swivel with Set Screws For use with brake assy. 1/4” OD, .240” length. For cable up to 3/32”. J3196 $1.58 Brass Sleeve Covers the cable to prevent fraying where it is held by the set screw H7272 $1.00 1/16”, 7 x 7 Galvanized Cable .064” O.D. Use with H7204 (below) H7215 ft. $.40 Bulk Cable Housing With liner for H7215 cable Black H7204 ft. $.96 Ferrule Drilled for .064” cable .250” O.D., .443” Length. Use with H7204 Housing with liner. Use with H7270 Midway and H7273A Adjuster (below) H7225 $.58 Ferrule, Stepped Drilled for .064” cable .250” OD, .787” Length, .222” Minor diameter, .350” Reduced length. Use with Splitter (below) H7265 $.45 Carb & Junction Block Fitting Drilled for H7215 .064” cable, .163” Length, .126” Diameter. Solder fitting to cable with 50/50 tin/lead solder & flux H7266 $.45 Midway Cable Adjuster Used in conjunction with cables for either throttle, choke, or brake. Measures 2-3/4” and extends to 3-3/8” allowing housing to lengthen them, thereby removing slack in cable housing. H7270 $3.95 Splitter Junction block for dual throttle or choke, or can be used with oil injection. Allows you to actuate 2, 3, or 4 cables with a single cable. Use Part No. H7265 Ferrule for cable housing. 3” 4-Way H7296 $8.50 4” 4-Way H7299 $8.99 6 mm x 1” Adjuster 10 mm hex head and 10 mm hex nuts, 1.675” Length. Use Part No. H7225 Ferrule Housing with liner. Install to “snug” only and safety with Loctite 242. H7273A $2.20 Oil Injection Bushing For 503 Rotax ® Engine H7338 $2.00 Petrochem Cable Life Formulated to stay fluid to -70˚F. Aids in preventing throttle cable from freezing and rusting H7505 $8.45 AIM-A-SQUIRT Allows spray lubricants, cleaners, dust-removers to precisely apply in confined or hard-to-reach areas while simultaneously allowing the can to remain upright. Includes two flexible tubes of different diameters. H4161 $4.95 Cable Luber Block Tool Petrochem Cable Luber Power injects Petrochem Cable Life into the cable. Lubricates cable completely in 5 seconds! H7500 $18.00 H7335 H7345 H7340 J3196 H7272 H7500 H7273A H7299 H7296 H7505 H4161 H7338 H7215 H7225 H7265 H7266 H7270 H7204 28 CONTROLS Description Part No. Price Dual Panel Mount Throttle Control by McFarlane For Rotax ® 912/914 engines and Homebuilts. Allows clean throttle installation without a splitter box. Features a smooth friction lock, all metal construction, teflon liner, heavy 0.062” stainless cables. Available in 6 ft. and 12 ft. lengths. Measured from panel fitting to end of conduit, cable extends 6 inches beyond conduit. Easily trimmed to length. 6 ft. H7383 $164.85 12 ft. H7384 $179.95 Non-Locking Choke Controls for Dual Carburetor Rotax ® 912/914 Series Engines by McFarlane All metal construction. High temperature Teflon lined conduit for smooth, consistent control. Available in 6 and 12 foot lengths. Measured from panel fitting to end of conduit, wires extend at least 3 inches beyond conduit. Easily trimmed to length. Adjustable cable stops to limit travel. Includes two adjustable barrel stops to attach to the carb choke arm (no swaging or soldering necessary) 6 ft. H7387 $164.85 12 ft. H7388 $177.00 Single Throttle and Choke Cables Description Part No. Price Cable for LEAF Quadrants To be used between throttle quadrant and single carb throttle. 3’ with Midway H7353 $7.25 6’ with Midway H7356 $14.20 9’ with Midway H7359 $17.20 9’ w/o Midway H7360 $13.65 Cable for LEAF Quadrant & Rotax ® Engine Combinations Used between throttle quadrant and throttle cable splitter. 3’ with Midway H7373 $11.35 6’ with Midway H7376 $13.90 9’ with Midway H7379 $16.45 Cable for Single Carb Chokes To be used between throttle quadrant and single carb choke. 3’ with Midway H7363 $11.30 6’ with Midway H7366 $14.20 9’ with Midway H7369 $15.25 Single Choke Inner Cable Only Does not include cable housing. 4’ Inner cable only w/ carb fitting H7325 $3.00 6’ Inner cable only w/ carb fitting H7327 $5.10 9’ Inner cable only w/ carb fitting H7326 $5.55 H7384 H7388 H7266 H7215 H7225 H7204 H7265 Type “1” Splitter Splitter Type “1” Splitter TO QUADRANT > TO QUADRANT > H7215 H7225 H7204 H7265 H7266 J3196 H7273A H7215 H7266 H7225 H7204 H7270 H7265 19” 14” 19” 14” H7272 TO QUADRANT > 19” 14” 18”